User manual UFREE SCOOTER POCKET BIKE PB-G07

[. . . ] * Racing should use mixture of the unleaded gasoline and the two cycle engine oil. Do not use any degraded fuel (which smells sour) or fuel of wrong mixture ratio. (Otherwise, it causes the plug to be degraded, the piston ring to seize or the muffler to be clogged. ) * Do not run the engine in a room or poorly ventilated area, (the exhaust gas includes odorless but hazardous carbon monoxide. ) * Do not put your hand or foot near any moving or rotating part of engine. [. . . ] (Run slowly 3-5 minutes after start-up or before stopping. ) This bike is not intended for operation on pedestrian, street, highway and freeway. Please check with your local Department of Motor Vehicles for regulation in your country. 2 UFREE SPORTS VEHICLE www. scooter-manufacturer. com TECHNICAL SPECIFICATION Engine type: 43CC/49CC single cylinder, air-cooled, 2 strokes Start way: Pull start Fuel: Unleaded gasoline + 2 cycle engine oil Proportion of gas: 25:1 Max Speed: 45km/h depend on condition Drive: Chain drive Weight capacity: 220lbs Tire: Front: 90/65-6. 5 Rear: 110/50-6. 5 Brake: Front and rear disc brake G. w. / N. w. : 31/21 kg Product Size: 109x56x78cm 3 UFREE SPORTS VEHICLE www. scooter-manufacturer. com 4 UFREE SPORTS VEHICLE www. scooter-manufacturer. com Assembling instruction. figure 1 figure 2 figure 3 figure 4 1. Loosen the bolt (3 pcs bolt), so as to remove the head cover (see figure 2) 3. Insert handlebar pipe into front fork, so that fasten lock. (See figure 4) 5 UFREE SPORTS VEHICLE www. scooter-manufacturer. com figure 5 figure6 figure 7 5. Fasten the bolt for lock, so as to keep the front fork at the middle, (see figure 5) 6. Assemble the front head cover, then fasten the two side bolt (see figure 7) 8. Everything is ready; you can ride it at any time. 6 UFREE SPORTS VEHICLE www. scooter-manufacturer. com Preparation before start-up 1. (see figure 8) Use a clean and special fuel glass and grasp cap to shake in more than 30 seconds. Don't use mixture oil in more than 1 month. 1:FC two-stroke engine oil 25:90#Gasoline (figure 8) 3. Check and clean the air filter The air filter must be often cleaned, or the polluted air filter will lower the output power of the engine. If the air filter is blocked by dust, use gasoline to clean the air filter, then dip in the oil, wring oil out and put the air filter back. (see figure 9) (figure 9) 7 UFREE SPORTS VEHICLE www. scooter-manufacturer. com Start-up Manual start Close the chock totally (see figure 10), If the engine is heated, the chock must be totally opened the choke door close open (figure 10) Operation and running The scooter is packed in a cardboard carton. After unpacking, Verify the smooth and perfect function of the Bowden cable throttle and both brakes. (Gas-oil mix 25:1) Failure to use the proper oil mix ratio will result in Engine damage for which you will be responsible Keep a low speed when turning otherwise it can causes losing control. It does not comply with valid Safety Standards Unsafe and careless use of a scooter can result in serious injuries. [. . . ] Take down the spark plug; add certain engine oil from the spark plug hole into the cylinder, and draw the starter 2-3 times to move the piston to the top dead center, then install the spark plug. Use the soft cloth with engine oil to clean the surface of the engine, smear wax on the frame and put the engine to the dry and windy place for the next use Trouble shooting 1. Maybe there is water in the gasoline. 10 UFREE SPORTS VEHICLE www. scooter-manufacturer. com 3. [. . . ]