User manual SCOTT KIDS

[. . . ] It is important to understand the basics of riding a bicycle, but it is equally important to exercise common sense when cycling. Cycling is a dynamic sport and requires reacting to varying situations. By choosing to ride a bicycle, you assume the responsibility for that risk. Forinstancearoadracingbikecannotbeusedtosubstituteamountainbikeinoff roadterrainoraTrekkingbikecannotbeusedfordownhillracingorroadracing. [. . . ] - In case you can pull the brakelever more than half of its way to the handlebar, you should readjust the brake. Pass the inner cable through the inner cable lead, and after setting so that the total of the clearances between the left and right shoes and the rim is 2 mm tighten the cable fixing bolt. tightening torque : Anzugsdrehmoment: 66-8 Nm (52-69 in. lbs. ) ­ 8 Nm inner cable lead 5mm allen key C A B ENGLISH 2 1 B C D B + C = 2 mm 3. Adjust the distance with the spring tension adjustment screws. CHAIN TENSION In case the chain needs to be tensioned again, please release on both sides nut A and pull the rear wheel straight backward until the tension is ok. Please note the tightening torque as mentioned in the table of tightening torques at the end of this file. Spring tension adjustment screw Federeinstellschraube Spring tension adjustment screw Federeinstellschraube 2 1 1 2 1 mm 1 mm 6 2011 SCOTT BIKE OWNERS MANUAL 7 KIDS 4. Depress lever about 10 times LIGHT SYSTEMS - light the front and rear lights by the beginning of the dusk. To check the function of front and rear light turn the raised front wheel. - Under wet conditions the effectiveness of the dynamo may decrease. Depress lever about Bremshebel circa 10 10 times mal anziehen KIDS Caliper brake Release counter nut A and turn adjustment screw B counter clockwise until the distance between brake pads and rims is approx. - In case adjustment screw B is released already to the limit, please release cable clamping screw C and turn adjustment screw clockwise to its original position. - Close the caliper brake with your hand to the rim , adjust the brake cable and tighten clamping screw C. - Finally make the fine tuning with adjustment screw B as mentioned above. Fix counter nut A. BICYCLE HELMET AND CLOTHING - Please take care that your child wears clothing with bright colors and, if possible, with reflective stripes or fabrics. In addition consider to be a good example for children. B A C ENGLISH Important: Make sure that the brake works perfectly. Important: Under wet conditions the brake performance can decrease which will result in a prolongation of the braking distance. 8 2011 SCOTT BIKE OWNERS MANUAL 9 KIDS REPLACEMENT OF DEFECTIVE OR BENT PARTS In case the bike is damaged by a crash or accident, please replace all damaged parts immediately at your local SCOTT dealer. Never try to repair bent parts, they might fail and cause an accident! MAINTENANCE AND CARE In addition to the checks listed above please check your bike regularly or if necessary, according to the following list or contact your local SCOTT dealer to do so in order to reach maximum safety and fun while riding. - All bolts and nuts, especially the quick releases of the wheels for proper fit and in case they are loose tighten them . - Stem and handlebar for visible damages and replace them if necessary. Please make sure that the bolts are tightened evenly when closing the front cap, according to the tightening torque recommended by the producer of the parts. - Braking systems - Air pressure of the tyres according to the recommendation of the producer. - Light systems and bell - Handlebar grips to be fixed to the handlebar - All parts of the rear suspension system including mounting bolts - The front suspension fork for perfect function and play in the bushings. - Brake and shifting cables for perfect wear and leakage on hydraulic systems. The table of maintenance below may help you to check your bike regularly and keep the full performance of your bike. Before riding: KIDS In the beginning the seat height should be adjusted in that way that your child, when sitting on the saddle, can reach the ground with both feet. [. . . ] Additional entitlements according to national warrant of merchantability are reserved. 16 2011 SCOTT BIKE OWNERS MANUAL 17 ENGLISH In case of a warranty claim the decision to repair or to replace the defective part is up to SCOTT. Non defective parts will only be replaced at the guarantee's own expense. KIDS SCOTT SERVICE PLAN SCOTT SERVICE PLAN Model Model Year KIDS Year KIDS Dealers Signature: 19 ENGLISH Size Size Frame Frame Date of purchase Date of purchase Annual service to be done Check of shock mounts incl. axle and mounts Check of rear shock according to the enclosed shock manual Check of hubs, bottom bracket and headset Check of all screws of the bike Check of handle bar, stem, saddle rails and seat post Check if brakepads and rims are worn out Check of disc brake according to enclosed service manual Check of suspension fork according to enclosed service manual Check of shifters and derailleurs incl. axle and mounts Check of rear shock according to the enclosed shock manual Check of hubs, bottom bracket and headset Check of all screws of the bike Check of handle bar, stem, saddle rails and seat post Check if brakepads and rims are worn out Check of disc brake according to enclosed service manual Check of suspension fork according to enclosed service manual Check of shifters and derailleurs incl. [. . . ]