User manual SAAB 9-5 2002

[. . . ] 1 Owner's Manual Saab 9-5, Model Year 2002 Safety Security Instruments and controls Saab 9-5 Audio System OnStar - Telematics Interior equipment and trunk Starting and driving Car care and technical information Maintenance and owner assistance Specifications Index © Saab Automobile AB 2001 11 37 49 83 105 117 145 187 243 247 261 Service Readiness, Saab Automobile AB, Trollhättan, Sweden Printed in Sweden 2 NOTE NOTE texts warn of potential damage to the car if the recommendations are not followed. Since the policy at Saab is one of continual improvement, we retain the right to incorporate modifications and to alter specifications during production without prior notice. If you have any queries concerning your car, its equipment, the warranty conditions or the like, your Saab dealer will be pleased to help. Best wishes, Saab Automobile AB Saab Automobile AB does not accept liability for any damage caused by the fitting of spare parts, exchange parts or accessories that are not approved by Saab Automobile AB. [. . . ] · Unsecured and heavy cargo can increase the risk of injury during hard braking, sudden avoidance maneuvers and in the event of a crash. · For the best load anchoring, use the special cargo bolts and load straps (accessory). · Provide protection on sharp edges to prevent damage to the load straps. · Never use the elastic floor net and elastic side net when the rear seat is folded down. These nets are only intended to keep light objects tidy, not for the anchoring of loads. · If possible, avoid having the rear seat folded down when driving with a heavy load because the anchoring possibilities are restricted when the rear seat is in this position. That the rear seat is in the upright position is a basic requirement for protection against cargo displacement in the event of a crash. · Cargo can intrude into the passenger compartment during a sudden stop or front crash if the outer safety belts are not fastened. This shows that the backrests are locked. 137 WARNING · The driving characteristics of the car can be affected because the center of gravity is altered when there is a cargo in the luggage compartment. Therefore match the speed and driving style according to how the car is loaded. · Adjust the car's load (passengers and luggage) so that the gross vehicle weight or the axle weight is not exceeded, see page 248. Driving with the trunk lid/tailgate open, see page 179. 138 Interior equipment and trunk IB1214 IB1216 Cargo bolts mounted on the longitudinal rails On the floor of the luggage compartment there are two longitudinal aluminium rails (CargoTracksTM) where special cargo bolts can be mounted. The protective strip on the CargoTracksTM is removed by lifting its back edge and pulling it straight upwards. When the cargo bolts are not being used the protective strip should be in place. The cargo bolts are mounted by lifting their locks and inserting them into the rail. Each cargo bolt is moved in the following way: pull up its lock and at the same time move it forwards or backwards to the desired position. Example of cargo anchoring Items for load anchoring: · Cargo bolts (standard). · Elastic side cargo net for the right-hand side of the luggage compartment. The elastic nets may only be used to keep light objects tidy, not for anchoring. The floor net should be attached to the cargo bolts that are mounted on the CargoTracksTM. Place the tie down eyes as far forward and as far back as possible on the CargoTracksTM. The side netting should be attached to the two tie down eyes which are included in the Elastic cargo net for lighter objects. accessory kit and to two of the eyes mounted on the right-hand CargoTrackTM on the floor. The cargo bolts, load straps and elastic nets are stored in the two floor lockers on the right- and left-hand side of the luggage compartment. [. . . ] (330 Nm) Compression ratio _________________ 9. 3:1 3. 0t V6 Ecopower Rating, EEC at 5500 rpm ____________ 200 hp (147 kW) Maximum torque, EEC at 2500 rpm ____ 229. 4 ft. lb (310 Nm) Compression ratio _________________ 9. 5:1 Specifications Electrical system Voltage __________________________ Battery capacity ___________________ Starter motor ______________________ Alternator rating 4-cylinder _______________________ 3, 0t V6 _________________________ Firing order: 4-cylinder _______________________ 3. 0t V6 _________________________ Spark plugs: 2. 3t ___________________________ Electrode gap ____________________ 2. 3 Turbo Aero ___________________ Electrode gap ____________________ 3. 0t V6 _________________________ Electrode gap ___________________ NGK BCPR 6ES-11 IB542 253 Drive belts 12 V 70 Ah 1. 4 kW 140 A/14 V 130 A/14 V 1-3-4-2 1-2-3-4-5-6 Engine variants Outside length 4-cylinder, poly-V-belt ________________ 102. 84 in (2612 mm) 3. 0t V6, poly-V-belt __________________ 79. 53 in (2020 mm) NGK PFR 6H-10 0. 0374 in (0. 95 mm) NGK BKR 7ES-11 0. 0414 in (1. 05 mm) Drive belt, 4-cylinder Drive belt, 3. 0t V6 IB543 0. 0414 in (1. 05 mm) 254 Specifications Automatic transmission All-synchromesh 5-speed with final drive and differential Saab synthetic manual gearbox oil 1. 9 qts (1. 8 litres) 1. 6 qts (1. 5 litres) Hydraulic, single dry-plate clutch of diaphragm-spring type 27­28 / 43­44 Type _____________________________ Electronically controlled 5-speed, fully automatic with hydraulic torque converter, planetary gear set and integral final drive Lock-up function in selector positions 3, 4 and 5. Selector-lever positions ______________ P R N D 4 3 L Transmission-fluid capacity, dry transmission (incl. torque converter and oil cooler) 7. 5 qts (7 litres) If fluid change required, approximately 3. 5 litres can be drained through the drain plug in the transmission casing Transmission fluid ___________________ Saab 3309 (mineral oil based) Clutch type ________________________ Hydraulic plate clutches, brake bands and one-way couplings Speed (mph / km/h) at 1000 rpm in 5th gear: 4- cylinder engines and 3. 0t V6 _______ 29 / 47­48 Manual gearbox Type ____________________________ Oil ______________________________ Oil capacity _______________________ Oil volume (on changing) ____________ Clutch type _______________________ Speed (mph / km/h) at 1000 rpm in 5th gear: 4-cylinder _______________________ Specifications Suspension Spring type, front and rear ___________ Maximum deflection of springs: Front __________________________ Rear ___________________________ Dampers, front and rear _____________ 7. 09 in (180 mm) 7. 87 in (200 mm) Gas-filled dampers Coil springs 255 Brake system Footbrake (ABS) ____________________ Hydraulic disc brakes with vacuum servo unit. Handbrake ________________________ Acts on rear wheels Brake fluid _________________________ DOT 4 Power-assisted steering of rack-and-pinion type; telescopic steering-column shaft with universal joints 2, 9 Power-steering fluid CHF 11S Brake-fluid capacity _________________ 0. 925 qts (900 ml) Disc diameter: Front ___________________________ 11. 34 in (288 mm) Front, certain variants *) _____________ 12. 05 in (306 mm) Rear ___________________________ 11. 26 in (286 mm) Rear, certain variants *) _____________ 11. 81 in (300 mm) *) 15" wheel must not be used on these variants. [. . . ]