User manual JENN AIR JA460N

[. . . ] USER'S MANUAL For Models JA460 and JA580 Gas Barbecue Grill 50001065/1201 Rev. 0 Warnings FOR YOUR SAFETY If you smell gas: · · · · Shut off gas to the appliance Extinguish any open flame Open lid If odor continues, immediately call your gas supplier or fire department. FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. · Always read and understand the WARNINGS and SAFETY INSTRUCTIONS that are contained in this Manual before attempting to use this Gas Barbecue Grill, to prevent possible bodily injury or property damage. Always keep this Manual in or near the Grill, for convenient future reference. · Page i Warnings SIGNAL WORDS : The Signal Words used in this Manual, and their intended meanings, are as follows : DANGER : Indicates that a failure to observe the safety instructions could result in death or catastrophic bodily injury. [. . . ] Always open the Hood completely and always inspect the Grill and burners to confirm that all components are properly positioned before lighting the main burners. WARNING: Never stand with your head directly over the Grill when preparing to light the main burners, to prevent possible bodily injury. Always confirm that all of the burner control knobs are in the OFF position before opening the gas supply. Turn on the propane gas supply valve at the tank (1 to 2 turns) or turn on the main natural gas supply valve (see Fig. Turn the selected Burner Control Knob to the HI position by pushing down on the knob and turning it counterclockwise. Fig. 8 NOTE: When lighting the grill for the first time, burn with the main burners on HIGH for at least 30 minutes, to burn off any manufacturing residues. 5. Light the burners sequentially from either left to right or right to left. · WARNING: IF THE SELECTED BURNER DOES NOT LIGHT, immediately turn the burner control knob to the OFF position, to prevent gas buildup. Wait five (5) minutes for the gas to clear and then repeat the preceding starting procedure. If the burner will not light when using the Igniter, follow the match lighting instructions (see Page 8). Confirm that the burner is properly lit and that the flame pattern is as desired, (see Figs. If the flame pattern is other than normal, consult the Troubleshooting Guide on Page 21 for corrective action. Light both burners and adjust them to the HI position for 5 to 10 minutes. Before placing any food on the Grill, clean the cooking grids with a brass wire brush. Adjust the Controls to a medium setting for most cooking requirements. A light coating of cooking oil on the cooking grids, before heating the Grill, will prevent foods from sticking to the Grill. Fig. 9c Normal: Soft blue flames Out of Adjustment: Noisy hard blue flames-too much air Poor Combustion: Wavy, yellow flames-too little air Page 7 Operation Turning the Burners Off 1. Always turn the burner control knob(s) to the OFF position when cooking has been completed. Promptly turn OFF the gas supply valve at the propane cylinder or at the main natural gas supply line. Close the Hood of the Grill. Flareups "Flareups" sometimes occur when food drippings fall onto the hot sear plates or burners and ignite. Some flaring is normal and desirable, as it helps impart the unique flavors associated with grilled foods. Controlling the intensity of the flare-ups is also desirable, however, in order to avoid burned or unevenly cooked foods and to prevent the possibility of an accidental fire. [. . . ] 19 Page 20 Troubleshooting Guide PROBLEM POTENTIAL CAUSE ACTION REQUIRED Turn on fuel supply and retry. Confirm the flow of gas by smell or by listening for the hiss of gas being emitted. (WARNING : Never take a propane cylinder indoors for any purpose. ) Confirm that the venturi tubes are not blocked by insects or other debris. Improper attachment of the propane hose and regulator Unit won't heat up (LP) Control knob left open at startup or Turning gas on too quickly Look under the front control panel and reinsert the gas injector into the venturi tube, if required (Fig. [. . . ]