User manual CASABLANCA FAN COMPAGNY NOUVELLE

[. . . ] NOUVELLE OWNERS MANUAL CONTENTS INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 MOUNTING RECOMMENDATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 FAN INSTALLATION - GETTING STARTED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 ADAPTOR PLATE INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 FAN PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 INSTALLATION & WIRING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 LIGHT FIXTURE INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] If necessary, straighten the fan, then check to ensure that there is no movement between the canopy and ceiling or ball and downrod. CANOPY WASHER CANOPY SCREW CANOPY HATCH 7 NOUVELLETM BLADE HOLDERS & HARDWARE BLADE HOLDER SCREW COUNTERSUNK PHILLIPS 12-24 X 5/8 (2 PER BLADE) BLADE SCREW FLAT HEAD 10-24 X 7/16 (4 PER BLADE) FELT WASHER #10 (4 PER BLADE) BLADE HOLDER BLADE & BLADE HOLDER INSTALLATION Step 10. Attach the blades to the blade holders with four of the flat head 10-24 X 9/16 blade screws and #10 felt washers provided. Hand tighten securely. BLADE SCREW (4 PER BLADE) FELT WASHER (4 PER BLADE) Step 11. Tighten securely by hand only. 4/5 Blade Combination Flywheel Your Casablanca fan includes our 4/5 combination flywheel. This flywheel accommodates your preference to use either 4 or 5 blades on your fan. If you desire a 4blade fan, locate the square counterbores on the flywheel and use these threaded holes to mount the blades. If you desire a 5-blade fan, locate the round counterbores on the flywheel and use these threaded holes. BLADE HOLDER SCREW (2 PER BLADE HOLDER) = 4-blade mounting hole = 5-blade mounting hole 8 NOUVELLETM LIGHT FIXTURE ELECTRICAL CONNECTIONS IF NOT INSTALLING LIGHT FIXTURE SKIP TO STEP 19 CHECK THAT THESE LOCKNUTS AND THE ASSEMBLY NUT ARE VERY TIGHT TIGHTEN WITH A WRENCH IF REQUIRED LOWER SWITCH HOUSING LIGHT FIXTURE ADAPTOR RING ASSEMBLY NUT CAUTION: Before installing light fixture check that the light fixture is securely tightened to the lower switch housing. If necessary remove the insulation from the last 1/2" of each wire (fan and light fixture). Have an assistant hold up the light fixture until it is close to the adaptor ring. Attach the switch housing wires to the light fixture wires by placing the bare ends of the wires together and then securing with a wire nut. Connect in this order: · WHITE wire from fan to WHITE wire from light fixture. Inspect each wire nut and ensure that no bare wire is visible; pull on each wire to test the connection is mechanically sound. 2 WHITE WIRES 2 BLACK WIRES LIGHT FIXTURE WIRENUT LIGHT FIXTURE HARDWARE LIGHT FIXTURE SCREW PHILLIPS COUNTERSUNK 6-32 X 5/16 (3) LIGHT FIXTURE INSTALLATION Step 15. Lift the light fixture assembly, making sure not to pinch the wires, and align the three holes in the side of the fixture with the three threaded holes in the adaptor ring and install the three (3) 6-32 X 5/16 Phillips screws. Hand tighten securely. LIGHT FIXTURE SCREW 9 NOUVELLETM LIGHT SHADE & BULB HARDWARE LIGHT SHADE FINGER SCREW (3 PER SHADE) 60 WATT BULB LIGHT SHADE & BULB INSTALLATION Step 16. Position the shade fully in the fitter and tighten each finger screw two turns each in rotation until the shade is centered in the fitter. Check that the shade is captured by the finger screws by lightly pulling on the shade. Note: Check the finger screws periodically as they will loosen and cause operating noise. FOR OPERATIONAL CONTROLS, PLEASE SEE PAGE 12. FINGER SCREW (3 PER SHADE) NO LIGHT FIXTURE OPTION - FIXTURE REMOVAL Step 19. Remove the locknut securing the light fixture to the lower switch housing. Save locknut and fixture for future use. LOCKNUT LOWER SWITCH HOUSING LIGHT FIXTURE 10 NOUVELLETM NO LIGHT FIXTURE OPTION - HARDWARE LOWER SWITCH HOUSING CAP THREADED BUTTON NO LIGHT FIXTURE OPTION - HARDWARE ASSEMBLY Step 20. Line up the center holes of the cap and lower switch housing to allow the threaded button to be installed. Hand tighten securely LOWER SWITCH HOUSING LOWER SWITCH HOUSING CAP THREADED BUTTON NO LIGHT FIXTURE OPTION - INSTALLATION HARDWARE LIGHT FIXTURE SCREW PHILLIPS COUNTERSUNK 6-32 X 5/16 (3) NO LIGHT FIXTURE OPTION - INSTALLATION Step 21. [. . . ] This seven hour pattern will repeat continuously so that a different pattern of lighting is seen each day of the week. To cancel the Home-Safe Program, turn the off for three seconds. INTELI·TOUCH OPERATION o FAN-MINDERTM PROGRAM The Fan-Minder feature will add to your comfort when used in the bedroom. The program reduces the speed of the fan each two-hour interval to compensate for the cooling night air. Immediately operate the buttons in the following sequence: + + + 4. [. . . ]